Detection of organophosphate flame retardants in furniture foam and U.S. house dust.

Journal Article (Journal Article)

Restrictions on the use of polybrominated diphenyl ethers (PBDEs) have resulted in the increased use of alternate flame retardant chemicals to meet flammability standards. However, it has been difficult to determine which chemical formulations are currently being used in high volumes to meet flammability standards since the use of flame retardant formulations in consumer products is not transparent (i.e., not provided to customers). To investigate chemicals being used as replacements for PentaBDE in polyurethane foam, we analyzed foam samples from 26 different pieces of furniture purchased in the United States primarily between 2003 and 2009. Samples included foam from couches, chairs, mattress pads, pillows, and, in one case, foam from a sound-proofing system of a laboratory-grade dust sieve, and were analyzed using gas chromatography mass spectrometry. Fifteen of the foam samples contained the flame retardanttris(1,3-dichloro-2-propyl) phosphate (TDCPP; 1-5% by weight), four samples contained tris(1-chloro-2-propyl) phosphate (TCPP; 0.5 -22% by weight), one sample contained brominated chemicals found in a new flame retardant mixture called Firemaster 550 (4.2% by weight), and one foam sample collected from a futon likely purchased prior to 2004 contained PentaBDE (0.5% by weight). Due to the high frequency of detection of the chlorinated phosphate compounds in furniture foam,we analyzed extracts from 50 house dust samples collected between 2002 and 2007 in the Boston, MA area for TDCPP, TCPP, and another high volume use organophosphate-based flame retardant used in foam, triphenylphosphate (TPP). Detection frequencies for TDCPP and TPP in the dust samples were > 96% and were log normally distributed, similar to observations for PBDEs. TCPP was positively detected in dust in only 24% of the samples, but detection was significantly limited by a coelution problem. The geometric mean concentrations for TCPP, TDCPP, and TPP in house dust were 570, 1890, and 7360 ng/g, respectively, and maximum values detected in dust were 5490, 56,080 and 1,798,000 ng/g, respectively. These data suggest that levels of these organophosphate flame retardants are comparable, or in some cases greater than, levels of PBDEs in house dust. The high prevalence of these chemicals in foam and the high concentrations measured in dust (as high as 1.8 mg/g) warrant further studies to evaluate potential health effects from dust exposure, particularly for children.

Full Text

Duke Authors

Cited Authors

  • Stapleton, HM; Klosterhaus, S; Eagle, S; Fuh, J; Meeker, JD; Blum, A; Webster, TF

Published Date

  • October 2009

Published In

Volume / Issue

  • 43 / 19

Start / End Page

  • 7490 - 7495

PubMed ID

  • 19848166

Pubmed Central ID

  • PMC2782704

Electronic International Standard Serial Number (EISSN)

  • 1520-5851

International Standard Serial Number (ISSN)

  • 0013-936X

Digital Object Identifier (DOI)

  • 10.1021/es9014019


  • eng